About Experts Sitemap - Group 136 - Page 40
Small Engines (Lawn Mowers, etc.): carb fuel leak, seat assembly, tecumseh engine
seat assembly, tecumseh engine, fuel leak: It sounds as though there may be an issue, in general, with uncontrolled fuel flow (flooding). I suspect, from your description, this is an air bleed hole and the only way fuel could be coming out of it is if the fuel level is reaching it. I recommend you...
Small Engines (Lawn Mowers, etc.): carb issues, hp briggs, vacuum leak
hp briggs, vacuum leak, eager 1: Hello Jason: This is a Common sign that the Main Passage and Jet Inside the Carburetor is Restricted with Varnish. To Properly Clean the Carburetor; Remove and Disassemble the Carburetor. Soak it Overnight in Carburetor Cleaning Solution(I use Gunk)...
Small Engines (Lawn Mowers, etc.): carb neddle settings, leafblower, low speed
leafblower, low speed, top speed: Hi Rich, Sorry for my delay. The holiday was busy. The high speed mixture screw is initially set at 1&1/2 turns out. Then adjust it to give good acceleration and top speed while keeping the screw as far out as possible. The low speed mixture screw...
Small Engines (Lawn Mowers, etc.): carb on tecumseh push mower, tooth comb, push mower
tooth comb, push mower, addys: Hello Shane: Send me the Model Numbers Off the Engine, Please. With these I can Locate the Proper Manual and Better Assist you. Also, Since this is a Tecumseh, I have 2 PDF Site Addys that May Assist you. 1- http://www.tecumsehpower.com/CustomerService/BSI.pdf...
Small Engines (Lawn Mowers, etc.): carb problem, troybuilt, breather tube
troybuilt, breather tube, rubber washer: Hello Scott: The Small O-ring you are talking about is the Seat for the Float Needle. Look inside the Carb Bowl Where the Float Needle enters the Carb. At the Bottom of the Hole is where this seat Goes. If the Float Needle has A Rubber Tip (Looks Black)...
Small Engines (Lawn Mowers, etc.): carb problem? Sears Tecumseh mower, craftsman eager 1, sears craftsman
craftsman eager 1, sears craftsman, tecumseh engine: Hi Doug, Disconnect the fuel line at the carb inlet and check the flow from the fuel tank. If good, then the carb most likely has dirt, debris or gummed fuel inside. You will need to remove the carb, disassemble it, clean all the small internal openings...
Small Engines (Lawn Mowers, etc.): carb rebuild kit, stihl chain saw, model 041, farm boss, air leaks, exhaust ports
air leaks, exhaust ports, speed needle: Hi Richard, Right after it quits, check for spark, so you can rule out ignition problems. The low speed needle is usually set at 3/4 turn out. Check for a good fuel flow at the carb inlet. Check the muffler and exhaust ports for carbon clogging. Check...
Small Engines (Lawn Mowers, etc.): carb rebuild kit, stihl chain saw, model 041, farm boss, air leaks, intake ports
air leaks, intake ports, exhaust ports: Hi Richard, One crank seal is under the clutch and the other is at the opposite end of the case. Checking them requires special toola and fixtures which allow pressurizing the crankcase. Other things that you can more easily check are, the intake ports...
Small Engines (Lawn Mowers, etc.): carb setting, air mixture, initial settings
air mixture, initial settings, leaf blower: Hello Don: When you Set the Air Mixture Screws to 1 1/2 from Snug. You Hold the Throttle Full Open to Start the Blower. Then Set the High Air Mixture Screw so the Engine is Reving Properly. Then Set the Low Air Mixture Screw so there is no Hesitation...
Small Engines (Lawn Mowers, etc.): carb settings, air fuel mixture, robin subaru
air fuel mixture, robin subaru, carb settings: Hello Jason: Turn the Air/Fuel Screw Clockwise until seated. DO NOT JAM!!! Then turn Counter Clockwise 1 1/2 turns. This is for both High and Low Air/Fuel Mixture screws. Once this is done and the engine is running then you fine tune the Carb. Hope...
Small Engines (Lawn Mowers, etc.): carb settings, fuel mixture, carb settings
fuel mixture, carb settings, factory settings: george , the setting are from start as i do is turn air and fuel mixture needles in until seated. back out one and one quarter turns each. start engine a tweak them as needed. fuel maybe a quarter turn more, should not be less. idle screw as best suits...
Small Engines (Lawn Mowers, etc.): carb trouble, fuel line blockages, honda 4 stroke
fuel line blockages, honda 4 stroke, float bowl: Hey John, Look for fuel line blockages. Also take another look at the float. Sometimes they experiance trouble because the float will stick and over flow the carb. Check for an eroded carb gasket. This is a common problem with these types of carbs. Look at...
Small Engines (Lawn Mowers, etc.): carb, adjustment screw, speed adjustment
adjustment screw, speed adjustment, initial settings: Hiya Todd- On these engines, there are two adjustments. On the bottom of the bowl is the high speed adjustment screw, on the side of the carburator is the idle mixture screw. Initial settings are as follows. High speed screw- fully in (gently) then out...
Small Engines (Lawn Mowers, etc.): carb, briggs stratton, model numbers
briggs stratton, model numbers, air filter: If you can locate the air filter, the carb is what it is attached to. You should locate a parts diagram using the model numbers from the engine. Most parts manuals for most makes of engines are available online if you search for the manufacturer (ie. Briggs...
Small Engines (Lawn Mowers, etc.): carb, hp engine, ipl
hp engine, ipl, shipping charges: Hello Wayne: This Addy http://www.outdoordistributors.com/ can give you the Part Number and a Price. I Usually Call Michelle @ 205-669-2500 for Pricing and Shipping Charges of Parts I Order. Got to the Site and Follow the Directions to View a Breakdown/IPL...
Small Engines (Lawn Mowers, etc.): carb, performance modifications, lawn mower
performance modifications, lawn mower, foe: Those engines are pretty limited on performance modifications. About the only low cost option is to increase the governed RPM by adjusting the governor spring. You can total remove all the governor parts, internal and external, but you risk blowing the...
Small Engines (Lawn Mowers, etc.): carb, tecumsa, carburator
tecumsa, carburator, snow blower: Hello Steve: Is the Gas Free Flowing to the Carburator? If yes, Then Clean and Rebuild the Carburator or Replace it if you wish. If you decide you want to Attempt the Rebuild, Send me the Model Numbers Off of the Engine, Please. With these Numbers I...
Small Engines (Lawn Mowers, etc.): carb. leak, hp engine, engine model
hp engine, engine model, overflow: Hi Steve, Look to see exactly where the fuel is coming from. Either the bowl seal, the needle bolt seal or an overflow from a vent. If the float is leaking, fuel will rise too high and overflow from a vent or the carb s intake. Let me know how you...
Small Engines (Lawn Mowers, etc.): carberator adjustments, horse power engine, mixture settings
horse power engine, mixture settings, air mixture: Hello Glen: I Have had to Answer this Question so Much that I made a File that Holds the Answer. :-) This is for a Carburetor Cleaning and Rebuild. The Carburetor Air Mixture Settings are in the Text. **The High Air Mixture Screw is In the Carburetor...
Small Engines (Lawn Mowers, etc.): carberator on cub cadet 1250 hydrostatic- kohler engine, carberator, best bet
carberator, best bet, kohler engine: Hello Wes: The Fuel is Leaking by the Needle and Seat in the Bowl. Your Best bet is to Install a Cutoff in the Fuel Line and Use it Whenever you Finish using the Mower. I have had to install cutoffs on all Bowl Type Carb Engines for the Past 3 Years....
Small Engines (Lawn Mowers, etc.): carbeurator, briggs and stratton, crafstman
briggs and stratton, crafstman, model numbers: Hello Chris: You will need the Model Numbers Stamped into the Blower Housing(metal engine cover) above the Spark Plug. Go to this Addy http://www.outdoordistributors.com/ and Follow the Instructions to View the Breakdown/IPL Manual Online and Get the...
Small Engines (Lawn Mowers, etc.): carbon build up
Hi Randy Randy- if this isn t a two-stroke mower engine (where you have to mix oil and gas) forget about the carbon build-up. Four-cycles don t have the exhaust issue with carbon that two-cycles do. Of course, you can clean it anyways, a can of WD-40 and...
Small Engines (Lawn Mowers, etc.): carbon build up, water in gas tank, wd 40
water in gas tank, wd 40, mufler: Hi Randy Randy- if this isn t a two-stroke mower engine (where you have to mix oil and gas) forget about the carbon build-up. Four-cycles don t have the exhaust issue with carbon that two-cycles do. Of course, you can clean it anyways, a can of WD-40 and...
Small Engines (Lawn Mowers, etc.): carborator adjustment, screw adjustment, weed trimmer
screw adjustment, weed trimmer, e 450: Hi Joe, The high speed mixture screw is initially set at 1&1/2 turns out. Then adjust it to give good acceleration and top speed while keeping the screw as far out as possible. The low speed mixture screw is set at 3/4 turn out, then adjust to give a...
Small Engines (Lawn Mowers, etc.): carborator, home scholling, victor mower
home scholling, victor mower, carbi: Hello Ryan: If the Engine is Starting and Then Quits, I Suggest you Clean and Rebuild the Carburator; if you have Gas Free Flowing to the Carburatr Inlet Port. Hope this Helps. I am here if you Require more Assistance. Let me know what Happens, Please....
Small Engines (Lawn Mowers, etc.): carbs
Hello Ron: For this Brand of Equipment I require the Serial Numbers Also to Look up the Equipment in the Manual. However, It sounds like the Carburator May be Set too Rich. I would Like to Look it up in the Manual and Check the Diagonistics Section...
Small Engines (Lawn Mowers, etc.): carbs, carburator, mcculloch
carburator, mcculloch, muffler: Hello Ron: For this Brand of Equipment I require the Serial Numbers Also to Look up the Equipment in the Manual. However, It sounds like the Carburator May be Set too Rich. I would Like to Look it up in the Manual and Check the Diagonistics Section...
Small Engines (Lawn Mowers, etc.): carbuerator reassembly, mike wallace, air filter
mike wallace, air filter, carbs: Hello Mike: The Part you are talking about is the Float Needle. Right where the Float Piviots; there should be a Hole where the Needle goes Into. The Float Pushs the Needle onto the Seat and Shuts Off the flow of Gas into the Bowl. I hope you have Cleaned...
Small Engines (Lawn Mowers, etc.): carbuerator, craftsman leaf blower, diaphram
craftsman leaf blower, diaphram, fuel line: Hi Paul, The high speed mixture screw is initially set at 1&1/2 turns out. Then adjust it to give good acceleration and top speed, while keeping the screw as far out as possible. The low speed mixture screw is set at 3/4 turn out, then adjust to give...
Small Engines (Lawn Mowers, etc.): carburater shut off valve, carburetor, air filter
carburetor, air filter, venturi: Hello Casimiro: If the Carburetor is Running Rich you will See Black Smoke from the Exhaust. You May need to Look Into a New Carburetor. From your Description it Sounds like the Molded Seat for the Needle is Pitted. Hope this Helps. I am here if you...
Small Engines (Lawn Mowers, etc.): carburator adjustment, air mixture, throttle plate
air mixture, throttle plate, cleaning solution: Hello Scott: Here is a Copy of a File I made that should Help. The Instruction are in there for Setting the Air Mixture Screws. **The High Air Mixture Screw is In the Carburetor Bowl in the Center of the Nut or Some Carburetors have Both the Low and...
Small Engines (Lawn Mowers, etc.): carburator and choke
Hello Kennington: Go to this Addy http://www.outdoordistributors.com/ and Click on the B. Then Select Briggs and Stratton. Then Select Dont have Part Numbers. Using the Engine Model and Type Numbers Select the Folder for your Engine. Then Select the...
Small Engines (Lawn Mowers, etc.): carburator and choke, sears craftsman, briggs and stratton
sears craftsman, briggs and stratton, briggs stratton: Hello Kennington: Go to this Addy http://www.outdoordistributors.com/ and Click on the B. Then Select Briggs and Stratton. Then Select Dont have Part Numbers. Using the Engine Model and Type Numbers Select the Folder for your Engine. Then Select the...
Small Engines (Lawn Mowers, etc.): carburator diaphram, tecumseh carburator, diaphram
tecumseh carburator, diaphram, reserch: Hello Michele: Your Local Small Engine Repair Shop will have or be able to get you the Diaphram. However, You are this far so do a Complete Carb Overhaul. Also this site might have the part; http://www.outdoordistributors.com/. Hope this Helps. ...
Small Engines (Lawn Mowers, etc.): carburator diaphram, tecumseh carburator, reserch
tecumseh carburator, reserch, spark plug: Hello Michele: Does this Carb have a Float? If yes then there is no Diaphram in it. As for where to put the new Diaphram, I will need the Model # of the engine. It is located just above the Spark Plug on the Metal Engine Cover. Im sorry for the Misunderstanding....
Small Engines (Lawn Mowers, etc.): carburator, fuel line, fuel tank
fuel line, fuel tank, noel: Hello Noel: The Carburator Float or the Carburator Float Needle is Stuck. Clean and Rebuilding the Carburator is Suggested to Correct this Problem. Hope this Helps. Let me know what Happesn, Please. Thanks. Good Luck Respectfully Joh...
Small Engines (Lawn Mowers, etc.): carburator, mixter, 25h
mixter, 25h, low speed: Hi Robin, I m not sure which screw you are turning. The small low speed mixture screw should intially be set 3/4 turn out. Set the idle with the idle speed screw. It limits or stops the carb s throttle butterfly plate from closing. Let me know how...
Small Engines (Lawn Mowers, etc.): carburator, mtd riding lawn mower, riding lawn mower
mtd riding lawn mower, riding lawn mower, fuel flow: Hi Scott, You will need to determine if the problem is a lack of spark or a lack of fuel flow. Remove the spark plug, reconnect the wire and lay it against the engine head. Pull the engine over and watch for spark at the plug s electrode. If good, then...
Small Engines (Lawn Mowers, etc.): carburetor adjustment, lawnmower engine, shape object
lawnmower engine, shape object, adjustment screw: The carb is not adjustable. When the engine starts to run rough, the most likely problem is the carb. Most likely you will have to remove, dis-assemble and clean the carb with compressed air from an air compressor. You may want to purchase a diaphragm...
Small Engines (Lawn Mowers, etc.): carburetor cleaning, air vent, float bowl
air vent, float bowl, nut bowl: The tube is an air vent to allow the fuel bowl to match atmospheric pressure. To clean the carb you will need to dis-assemble it; mainly just removing the float bowl nut, bowl, float and inlet needle. Normally all we do it blow compressed air from and...
Small Engines (Lawn Mowers, etc.): carburetor disassembly on a craftsman snowblower, snow blower, craftsman snowblower
snow blower, craftsman snowblower, winter season: If you ran the unit dry the last time you used it then I would replace the spark plug, fill the tank with some brand new fuel and try to start the engine. Did you see any deposits/debris in the carburertor float bowl? Make sure the small holes in the float...
Small Engines (Lawn Mowers, etc.): carburetor problem - possible flooding, briggs stratton engine, briggs stratton
briggs stratton engine, briggs stratton, gas leaks: Mike, There is no advantage to installing two seats in the carb as it would end up leaking past them and you would be unable to set a proper float level because you wouldn t be able to bend the float height tang enough to make up the distance taken by the...
Small Engines (Lawn Mowers, etc.): carburetor problem, finger nail polish, float bowl
finger nail polish, float bowl, tecumseh engine: You will have to remove the carb to replace the plug. Most likely you will need a new one. Welch plugs are convexed when new. Install it with the bulge facing up, then use a large, flat punch and a hammer to flatten the plug so it stays in place. Welch...
Small Engines (Lawn Mowers, etc.): carburetor setting, blower vac, wales uk
blower vac, wales uk, everthing: Hello Adrian: Turn Both H and L Screws Clockwise Until Seated. **DO NOT JAM SNUG ONLY** Now Turn Both Counter Clockwise 1 1/2 Turns. Holding the Throttle Full Open, Start the Engine. Adjust the H Screw In until the Engine Revs Properly. Then Allow Engine...
Small Engines (Lawn Mowers, etc.): carburetor trouble, engine 143, lawn mover
engine 143, lawn mover, govenor: Did you mess with the governor arm screw when you rebuilt the carb? Is the governor rod binding? Are there any adjustment needles on your carb...some carbs do not have any. Did you blow compressed air through the carb orfices when you rebuilt it? Was...
Small Engines (Lawn Mowers, etc.): carburetor, Tecumseh TVS90
Hello Harry: If the Primer Bulb has A Pin Hole or is Dry Rotted the Engine cant Get Gas because it Draws Air through the Primer Bulb. Place a Piece of Duct Tape over the Bulb (make sure no air can be Drawn by the Tape) and Try to Start the Engine by...
Small Engines (Lawn Mowers, etc.): carburetor, Tecumseh TVS90, float bowl, push mower
float bowl, push mower, tecumseh tvs90: Hello Harry: If the Primer Bulb has A Pin Hole or is Dry Rotted the Engine cant Get Gas because it Draws Air through the Primer Bulb. Place a Piece of Duct Tape over the Bulb (make sure no air can be Drawn by the Tape) and Try to Start the Engine by...
Small Engines (Lawn Mowers, etc.): carburtor connecting rod, briggs and stratton, hello bill
briggs and stratton, hello bill, throttle lever: Hello Bill: From your Description it Sounds like the Rod is the Throttle Control Rod from the Governor Control Arm to the Carburetor Throttle thru Shaft. You can View a Breakdown/IPL of this Engine at this Addy http://www.outdoordistributors.com/ and...
Small Engines (Lawn Mowers, etc.): case 448 stalling, case 448, condensor
case 448, condensor, gas tank: Hello Phyllis: Has anyone Checked the Ignition Module or Point Set. When the Ignition Module or Condensor (if Point Set) get Hot they will Ground Out. If the Shop didnt put the Mower Under a Load; ie Cutting Grass; they will not get the Components Hot...
Small Engines (Lawn Mowers, etc.): cat heads and mowers, cat heads, question subject
cat heads, question subject, cletus: Well because you are a sick individual. Why else would you put a cats head in a mower? Is that fun for you? What would the cat experts say about you sticking a cats head in a mower? Ask them and find out. I would love to catch you doing that to a poor...
Small Engines (Lawn Mowers, etc.): cat heads, cat heads, organic material
cat heads, organic material, lawn mower: People are just obsessed with cat heads. I have no room to talk. There is a big market for cat heads these days. The witches and wiccans use them to put spells on people and curses. I personally just like to use them for fertilizing my yard. Nothing like...
Small Engines (Lawn Mowers, etc.): ceiling fan, busy holiday, ceiling fan
busy holiday, ceiling fan, hot air: Hi Carol, Sorry for my delay. It was a busy holiday here. The blades should blow the hot air down in the winter. In the summer it depends whether you want to feel a breeze or circulate the air. Blow it down for a breeze and up to circulate. I...
Small Engines (Lawn Mowers, etc.): centrifugal clutch replacement, clutch replacement, centrifugal clutch
clutch replacement, centrifugal clutch, ryobi weedeater: Hello Tommy: The Clutches are the Same for the Trimmer Engines. They are Designed to Engage at a Certain RPM. Is this a New Clutch? When Going Up Hill, Does the Clutch Slip? If Yes, then the Clutch Drum/Bell May be Worn Out. Usually the Problem with...
Small Engines (Lawn Mowers, etc.): chain driven snowblower, sprocket teeth, driven sprocket
sprocket teeth, driven sprocket, craftsman snowblower: It is possible for chains to stretch. At the same time the sprocket teeth will usually wear also. It s often difficult to see sprocket wear until you compare a new and old sprocket. The chain is probably a common 35 or 40 chain. You can purchase new...
Small Engines (Lawn Mowers, etc.): chain saw - no spark, spark plug wire, 2k ohms
spark plug wire, 2k ohms, hurricane frances: ok the parts are almost impossible to find for it. some aftermarket parts are available, not many im afraid. to test the condenser is not easy, do you have an analog or digital meter? and yes you can replace it with a similar sized condenser. the condenser...
Small Engines (Lawn Mowers, etc.): chain saw - no spark, spark plug wire, electrical questions
spark plug wire, electrical questions, hurricane frances: Hi Scott, Sorry, most of your electrical questions are out of my range of knowledge. I do know that the condenser helps preserve the points by refining the current or absorbing the excess. Also they rarely go bad, so the possibility of you having 2 bad...
Small Engines (Lawn Mowers, etc.): chain saw - no spark, spark plug wire, leak down test
spark plug wire, leak down test, condensor: The condensor is just a capacitor that stores primary ignition current while the points are open to prevent arcing across the points. To test it, you need to have the equipment to charge it and do a leak-down test (let it sit for a few minutes and ground...
Small Engines (Lawn Mowers, etc.): chain saw leak, automatic oiler, oil chamber
automatic oiler, oil chamber, chain oil: Max I would check the oiler line that goes to the chain somewhere it may have split due to old age,sawdust or contaminants. The oil tank has a oil pick up tube and it may have a small filter in the tank,to prevent dirt from clogging the line.As far as using...
Small Engines (Lawn Mowers, etc.): chain saw oiler replacement, automatic oiler, blade adjustment
automatic oiler, blade adjustment, oil tank: Hi Arthur, Sorry, I am not familiar with the exact configuration of your saw. There should be hole or nipple in the block or a place for the tube to be positioned over the chain. Some oilers output directly from inside the case and use a tube to connect...
Small Engines (Lawn Mowers, etc.): chain saw repair, fuel air mixture, crankshaft seal
fuel air mixture, crankshaft seal, seal leaks: Hi Phil, I forget all the things we talked about. so, in general, you need 3 things for an engine to run. Fuel, timed spark and compression. Any 2 stroke engine relies on an air tight seal in the crankcase to draw the fuel/air mixture into the cylinder....
Small Engines (Lawn Mowers, etc.): chain saw timing, crankshaft, flywheel
crankshaft, flywheel, condenser: Hello Rich: There is a Lobe on the Crankshaft that Opens and Closes the Point Set. Turn the Crankshaft Until the Lobe is Under the Point Set Lift and then Set the Point Set to .015in. Hope this Helps. I am here if you Require more Assistance. Thanks....
Small Engines (Lawn Mowers, etc.): chain saw, carb settings, fuel cap
carb settings, fuel cap, diaphram: Your saw may or may not have an impulse hose. The carb needs to use crankcase pulses to actuate the fuel pump diaphram in the carb. These pulses either come through a hose to the carb or a small hole through the intake spacer to the carb body. If it s a...
Small Engines (Lawn Mowers, etc.): chain saw, fuel cap, crankcase
fuel cap, crankcase, fuel filter: Try loosening off the fuel cap slightly before you start it. Quite often, the tank vent gets plugged with sawdust and when the tank doesn t vent correctly, the engine starts and then dies. If this helps, locate the tank vent and clean or replace as required....
Small Engines (Lawn Mowers, etc.): chain saw, spark arrestor, exhaust port
spark arrestor, exhaust port, spark plug: Hello Otis: Check the Exhaust Port and Muffler for Blockage. Check the Spark Arrestor Screen Also. If these are Clear, then Check the Flywheel Key. Remove the Flywheel From the Engine to Properly do this. It May Look Good while the Flywheel is Mounted,...
Small Engines (Lawn Mowers, etc.): chain saw, speed jet, lean condition
speed jet, lean condition, accelleration: Hi Phil, Set the low speed jet at 3/4 turn out and the high speed jet at 1 & 1/2 turns out. When running, adjust the high speed to give good power and accelleration while having it set as far open as possible to avoid a lean condition. Let me know...
Small Engines (Lawn Mowers, etc.): chainsaw
Hello Ben: Assuming the Muffler and Spark Arrestor Screen are Also Carbon Free; What is the Compression? Set Both Fuel Mixture Screws to 1 1/2 Turns Out from Seat. Then Start the Engine and Hold the Throttle Full Open. Turn the High Mixture Screw IN...
Small Engines (Lawn Mowers, etc.): chainsaw carb rebuild, walbro carb kit, assembly diagram
walbro carb kit, assembly diagram, promac: I can t point you in any specific direction for the information but I think you have assembled the needle & seat and diaphram incorrectly. This would allow the carb to flood the engine. The kit should have come with an assembly diagram for the carb. If...
Small Engines (Lawn Mowers, etc.): chainsaw propblems, speed jet, correct settings
speed jet, correct settings, diaphram: Hi Jerry, The high speed jet should be set at 1&1/2 turns out and the low speed jet, set at 3/4 turn out. Check for good fuel flow at the carb inlet. The carb may be in need of rebuilding, including a new diaphram. Let me know how you make out. Michae...
Small Engines (Lawn Mowers, etc.): chainsaw repair, craftsman chainsaw, looseness
craftsman chainsaw, looseness, crankcase: Hiya Bruce couple possibilities here- both involve your mixture leaning out- 1- check you carb for looseness, or evidence of a bad gasket 2- try to richen the idle mixture by opening the screw 1/4 turn 3- get the engine nice and warm...2-5 min. From...
Small Engines (Lawn Mowers, etc.): chainsaw starting problem
Hello Ken: Remove the Muffler and Inspect the Cylinder and Piston. How Bad is the Scarring in the Cylinder and On the Piston. On Chainsaws, the Compression can Show Good but if there is a Large, Deep or Numerous Small Scratches in the Cylinder or the...
Small Engines (Lawn Mowers, etc.): chainsaw starting problem, propane gas, throttle settings
propane gas, throttle settings, original chain: Hello Ken: Remove the Muffler and Inspect the Cylinder and Piston. How Bad is the Scarring in the Cylinder and On the Piston. On Chainsaws, the Compression can Show Good but if there is a Large, Deep or Numerous Small Scratches in the Cylinder or the...
Small Engines (Lawn Mowers, etc.): chainsaw won't run when hot, craftsman chainsaw, coil ignition
craftsman chainsaw, coil ignition, exhaust port: Hello Kevin: By Checked all Venting, I Assume you Checked the Exhaust Port and Muffler. If this is True, then Check the Compression When the Unit Stalls. If Less than 70psi, then the Engine needs Rings. Does the Saw have Fire to the Plug when this Happens?...
Small Engines (Lawn Mowers, etc.): chainsaw won't run when hot, craftsman chainsaw, coil ignition
craftsman chainsaw, coil ignition, exhaust port: Hello Kevin: The Drop in Compression is Not Unusal as Long as on the Second or Third Pull the Compression Goes Back Up to Above 90psi. Pour a Small Amount of Marvil Mystery Oil Into the Cylinder and Let it Set Overnight. Then Clean Out the Oil. The...
Small Engines (Lawn Mowers, etc.): chainsaw, craftsman chainsaw, fuel flow
craftsman chainsaw, fuel flow, kill switch: Hi Ricky, Check for spark at the plug. If none, check the kill switch. If that s good, replace the ignition coil. If you have spark, look for the cause of the lack of fuel flow. If the saw has been sitting, the carb may be gummed up with old fuel....
Small Engines (Lawn Mowers, etc.): chainsaw, diaphram, replacement fuel
diaphram, replacement fuel, filler cap: Hello Mac: Did you look at a D2WA&T Carb Kit? The Model Number of the Saw will Help me. Does this Carb have a Fuel Return? The Diaphram Does need to be Replaced and the Small Needle Under the Diaphram has a Specific Setting Also. You will Need to Locate...
Small Engines (Lawn Mowers, etc.): chainsaw, fuel mixture, exhaust ports
fuel mixture, exhaust ports, new spark: Hello Ben: Assuming the Muffler and Spark Arrestor Screen are Also Carbon Free; What is the Compression? Set Both Fuel Mixture Screws to 1 1/2 Turns Out from Seat. Then Start the Engine and Hold the Throttle Full Open. Turn the High Mixture Screw IN...
Small Engines (Lawn Mowers, etc.): chainsaw, homelite chainsaw, model xl
homelite chainsaw, model xl, gages: Hello Robert: The Coil/Magneto is Set at .020in. the Point Set is Set at .020in. and the Spark Plug is Gapped .035in. Some Saws were Set at .012in, but try the .020in first. Not many were set to .012in. Hope this Helps. Let me know what Happens, Please....
Small Engines (Lawn Mowers, etc.): chainsaw, homelite parts, model numbers
homelite parts, model numbers, ares: Hello Ron: The Saw is Approximately 40cc. You can View this Saw at this Addy http://www.homelite.com/parts/index.htm and Select Go to the Homelite Parts Store. Then Enter the Model Numbers 240. Then Double Click on your Model in the Search Results Ares....
Small Engines (Lawn Mowers, etc.): chainsaw, mcculloch eager beaver, inch coil
mcculloch eager beaver, inch coil, mechanical function: The srping is used to hold the throttle safety lock in place, not to return the throttle to idle. The 90 degree bend, if I remember correctly, just sits under the safety lock lever to hold it up. I ll see if I have a repair manual for it but we got rid...
Small Engines (Lawn Mowers, etc.): chainsaw, sears outlet store, diaphram
sears outlet store, diaphram, replacement fuel: Hello Mac: I am showing several Rebuild Kits for this Carb. Take the Carb Numbers and Get a New Kit. Replace the Diaphram and be sure all the Ports and Passages are Blown out with Air. Let me know what happens. Hope this Helps. Good Luck ...
Small Engines (Lawn Mowers, etc.): chainsaws
Hello Imcdill: I have no Use for Stihl. Over Priced and all you Pay for is the Name. I use Poulan or Husqvarna. Poulan Gives Very Good Service for the Price as Does Husqvarna. I Mix All my 2 Cycle Oil at 32 to 1 and Havent had Any Problems with Either...
Small Engines (Lawn Mowers, etc.): chainsaws, cycle oil, chainsaw
cycle oil, chainsaw, mechanic: Hello Imcdill: I have no Use for Stihl. Over Priced and all you Pay for is the Name. I use Poulan or Husqvarna. Poulan Gives Very Good Service for the Price as Does Husqvarna. I Mix All my 2 Cycle Oil at 32 to 1 and Havent had Any Problems with Either...
Small Engines (Lawn Mowers, etc.): chainsaws, landon, chainsaw
landon, chainsaw, saws: Hi Landon, I am a bit lacking in that area. I do know that here in CT, people seem to like Husqvarna. Most all brand name saws that are also used commercially should perform well for you. Choose a brand that has dealers in your area, in case parts or...
Small Engines (Lawn Mowers, etc.): change oil on Craftsman Eager 1 6.5, craftsman eager 1, oil drain plug
craftsman eager 1, oil drain plug, float bowl: REMOVE the spark plug before doing any work!! There is a oil drain plug on the bottom of the engine. If the unit is self-propelled you may have to remove a belt guard to access the drain plug. Another method you can use is to have your son help you...
Small Engines (Lawn Mowers, etc.): change oil, dipstick tube, change oil
dipstick tube, change oil, tool and die maker: Believe it or not, the oil comes out the same place it went in. Tip the mower on it s side and pour it out the dipstick tube. While it s on it s side remove the blade and sharpen it. Unless your a tool and die maker take it to a power equipment dealer...
Small Engines (Lawn Mowers, etc.): changing belt on 2005 husqvarna, yth2448, c stewart
yth2448, c stewart, tool dealers: I have not seen or tried to install the belt change levers on the 2005 mower. To assist in replacing the belt we have several special tools that aid in removing and installing the spring. You can find most of these tools on-line or from tool dealers. ...
Small Engines (Lawn Mowers, etc.): changing engines, hp model, intek
hp model, intek, code numbers: Most likely you can. However, you will need some info to be sure. You need to take the 18 HP model, type and code numbers to your nearest Briggs dealer. They have a book, engines sales manual, that will provide the output cranshaft information and footprint...
Small Engines (Lawn Mowers, etc.): changing front tires, craftsman model, cotter pin
craftsman model, cotter pin, valve stem: remove front cap should be black over axle. there will be a cotter pin or c clip .... remove it, and pull tire and wheel off of axle. i have had some people get tire sealer which is yellow in color, removing valve stem core placing it in tire and...
Small Engines (Lawn Mowers, etc.): changing the oil in lawnmower, eager 1, rear discharge
eager 1, rear discharge, fresh oil: The drain plug is usually located on the underside of the engine. Make sure you first remove the spark plug lead and keep away from the spark plug (to prevent accidental starting). Tip the mower spark plug up and look for a drain plug. Open the plug and...
Small Engines (Lawn Mowers, etc.): charging circuit, ac volts, battery terminals
ac volts, battery terminals, stator: Hello Pete: Are you Working with the Magneto (Outside the Flywheel) or the Stator(Under the Flywheel)? The Magneto and the Stator will Show 0.0VDC when the Engine Isn t Running. The Stator can Only be Checked when the Engine is Running. The Voltage...
Small Engines (Lawn Mowers, etc.): charging system on craftsman lawnmower, engine numbers, stator
engine numbers, stator, charging system: Hello Chris: You can View a Breakdow of the Engine at this Addy http://shop.briggsandstratton.com/BShopProductListingPage.asp?rsvp=0&PARENTID=0&SessionID=43C7B3A0-6A44-4EB2-B2CC-23B437198A68&MECID=100&CATALOGID=56B2B9A7-283C-11D4-8886-00B0D0203414 and...
Small Engines (Lawn Mowers, etc.): charging system on craftsman lawnmower, yellow wires, engine numbers
yellow wires, engine numbers, stator: Hello Chris: Was this Voltage with the Engine at Full Thrrottle? If Yes, then Replace the Stator. None of the Voltage from the Stator should be that Low. I have found some of the Stators that Feed the Headlight Only can Sometimes Show 8.8 to 9.8 Volts....
Small Engines (Lawn Mowers, etc.): charging system on craftsman lawnmower, yellow wires, engine numbers
yellow wires, engine numbers, stator: Hello Chris: Great!! Im Glad you got it Going. Ill Add your Fix to My Notes. May all you Mechanical Problems be SMALL ONES and May the All Mighty Bless You and Yours. Thanks for the Email Update. Till next Time. Best Wishes Good Luck ...
Small Engines (Lawn Mowers, etc.): charging system on riding mower, soleniod, battery check
soleniod, battery check, volt meter: Hello Robert: If this Mower has a Carburator Soleniod in the Carburator Bowl, then it will Shut Off as soon as you Disconnect the Battery. Check the Battery for a Bad/Weak Cell. If the Battery has a Bad/Weak Cell, the Bad/Weak Cell will Draw the Good...
Small Engines (Lawn Mowers, etc.): charging system, briggs and straton, sanford fl
briggs and straton, sanford fl, charging system: Hi, If the mower starts with starting fluid, What makes you think that it is somthing with the charging system? It sound like a fuel problem! Have you checked the fuel filter?? If the filter is ok then there is somthing in the carb that is obstructing the...
Small Engines (Lawn Mowers, etc.): charging system, garage door opener, trickle charger
garage door opener, trickle charger, long periods: You would be correct, 21 volts/2 =11vdc. Not enough. I use to have a gold wing that had an alarm. It would gradually drain the battery over long periods when I didn t ride. I hooked a trickle charger to the outlet on my garage door opener. Every time the...
Small Engines (Lawn Mowers, etc.): charging system, hp model, warranty work
hp model, warranty work, john troy: Bummer John, Troy-bilt makes the absolute crappiest tractors on the planet!!!! I currently have 17 in my shop for warranty work, that s 20% of my total pending work orders. You got what you paid for! Test the charging system by using a volt meter between...
Small Engines (Lawn Mowers, etc.): charging system, kolher engine, regulater
kolher engine, regulater, battery discharge: Ron, sounds as if you covered you system well.....Magnets in the Flywheel??? Good??? If all the parts are new, you should be getting something at the battery. Discharge the battery (lights or something ) to 11 volts, and run the engine. You should get/see...
Small Engines (Lawn Mowers, etc.): charging, regulator rectifier, posibility
regulator rectifier, posibility, stator: Could the regulator-rectifier be the problem? Its def. a strong posibility. Put a multimeter to every posible wire, end to end and trouble shoot that first. Check out your voltage on your battery, make sure it s pulling correctly. Before sinking alot of...
Small Engines (Lawn Mowers, etc.): check, volt bulb, volt source
volt bulb, volt source, volt meter: Hi Asif, I use a few basic tools. A test light, that shows when you have power to any given wire or terminal. You can buy one or use any 12 volt bulb and socket with test leads. A volt meter, although not as easy or fast as a test light, will also test...
Small Engines (Lawn Mowers, etc.): checking oil, dipstick, right reading
dipstick, right reading, second reading: Hi Diana, The reason for wiping the oil from the dipstick is to remove the extra oil above the actual level mark. This oil gets there from either, oil splashing around while the engine is running or from the vehicle being on unlevel ground while moving....
Small Engines (Lawn Mowers, etc.): chipper/shredder, chipper shredder, wd 40
chipper shredder, wd 40, gas tank: Hi Tom, The carb most likely has dirt, debris or gummed fuel inside. You will need to remove the carb, disassemble it, clean all the small internal openings and blow it out with compressed air. Probe each and every hole with a small wire. A carb rebuild...
Small Engines (Lawn Mowers, etc.): choke / carbureter, briggs and stratton, breather vent
briggs and stratton, breather vent, crankcase breather: Hello Again Fred: Thanks for the Model Numbers. Go to this Site Addy, http://www.outdoordistributors.com/ and Select the B. Then Select Briggs and Stratton. Then Select Don t have Part Numbers. Then Select the File #42. Then Select the Folder #42A700. This...
Small Engines (Lawn Mowers, etc.): chraftsman chipper shredder model 247-776350
Hello Wes: Go to this Addy http://www3.sears.com/ and Click on the Lawn Equipment Block. Follow the Directions to the View Parts Diagram Page. Here you can See the Breakdown of the Chipper/Shredder. The Impeller is Keyed to the Shaft and you will Require...
Small Engines (Lawn Mowers, etc.): chraftsman chipper shredder model 247-776350, chipper shredder, engine shaft
chipper shredder, engine shaft, slide hammer: Hello Wes: Go to this Addy http://www3.sears.com/ and Click on the Lawn Equipment Block. Follow the Directions to the View Parts Diagram Page. Here you can See the Breakdown of the Chipper/Shredder. The Impeller is Keyed to the Shaft and you will Require...
Small Engines (Lawn Mowers, etc.): cleaning the carberatior, toro snowblower, carberator
toro snowblower, carberator, upper cylinder: Hello Lucy, sorry for the delay. What you must do is soak the carb in gasoline for about 2-3 hours(trust me it may take a while but after it will run great). After this take a pipe cleaner of any of these materials(preferably cloth bristle, or hard wire bristle)and...
Small Engines (Lawn Mowers, etc.): clunk, metal noise, mower deck
metal noise, mower deck, lawnmower: If you hear a metal-to-metal sound when you rotate the engine (even if it doesn t start), you may want to check to see if the crank or blade is bent. This may be causing the blade to be contacting a stationary area of the mower deck. The only other metal-to-metal...
Small Engines (Lawn Mowers, etc.): clutch
Hello Richard: Send me the Model Numbers Off Of the Mower,Please. I can Get the Diagram that will Assist us in Finding the Solution to Your Question. However, you can Check the Fuse(if it has one) and the Switch and Ensure they are Good. Thanks. ...
Small Engines (Lawn Mowers, etc.): clutch adjustment, clutch adjustment, sectional index
clutch adjustment, sectional index, addy: Hello Harold: There is No Adjustment that I Recall or see when I look at a Breakdown of an RX73 Mower. Go to this Addy http://jdpc.deere.com/jdpc/servlet/com.deere.u90490.partscatalog.view.servlets.HomePageServlet_Alt and Enter the Model Number RXxx....
Small Engines (Lawn Mowers, etc.): clutch installment.
Hi Mr. A, http://www2.northerntool.com/cat-1/291701 93 544606.htm Has many kart parts including clutches for $40. A clutch would attach to the engine s crankshaft and allow the engine to run without driving the drive chain or drive belt until the engine...
Small Engines (Lawn Mowers, etc.): clutch installment., briggs straton engine, www google com
briggs straton engine, www google com, google: Hi Mr. A, http://www2.northerntool.com/cat-1/291701 93 544606.htm Has many kart parts including clutches for $40. A clutch would attach to the engine s crankshaft and allow the engine to run without driving the drive chain or drive belt until the engine...
Small Engines (Lawn Mowers, etc.): clutch on toro 8-32 get weaker and weaker?
Hi Gebarlow- sorry for the delay - vacation There is an assembly directly under the motor, it has two belts running off it. One belt goes to the transaxle and drives the mower. The other belt runs off an electric clutch/pulley assembly on this same...
Small Engines (Lawn Mowers, etc.): clutch on toro 8-32 get weaker and weaker?, electric clutch, friction pads
electric clutch, friction pads, transaxle: Hi Gebarlow- sorry for the delay - vacation There is an assembly directly under the motor, it has two belts running off it. One belt goes to the transaxle and drives the mower. The other belt runs off an electric clutch/pulley assembly on this same...
Small Engines (Lawn Mowers, etc.): clutch operated cutting deck, craftsman lawn tractor, extension spring
craftsman lawn tractor, extension spring, tractor model: Hello Michael: There are a Few Reasons. the Most Common are: 1- the Extension Spring is Bad. During Operation the Spring is Holding Tension on the Blade Idler Pulley. It is Also Vibrating from the Operation of the Mower. This Vibration Causes Heat and the...
Small Engines (Lawn Mowers, etc.): clutch return spring, 4/21/07, return spring, mechanical problems
return spring, mechanical problems, ratchet: Hello Linda: I Didn t see you in the Shop. LOL That was the Same Way I Use to Install the Clutch Springs when I First Started Doing these Repairs. Now I have a Ratchet Designed to Do the Pulling. Im Glad you Got it Going. Till Next Time. May All Your Mechanical...
Small Engines (Lawn Mowers, etc.): clutch return spring, craftsman lawn mower, linda parks
craftsman lawn mower, linda parks, return spring: Hello Linda: OK I Undeerstand Now. Sorry for the Misunderstanding. On the Diagram, the Spring has One End Connected to the Plate #48 in the Hole Next to the #53 Clutch Link Connection. The Other End is Stretched to a Slotted Hole in the Frame Most Times....
Small Engines (Lawn Mowers, etc.): clutch, electric clutch, mower blades
electric clutch, mower blades, model numbers: Hello Richard: Send me the Model Numbers Off Of the Mower,Please. I can Get the Diagram that will Assist us in Finding the Solution to Your Question. However, you can Check the Fuse(if it has one) and the Switch and Ensure they are Good. Thanks. ...
Small Engines (Lawn Mowers, etc.): clutch/brake
Hi Greg- Jeeze pops a wheelie? Man- yeah you need to fix that before you break the transaxle! Sounds like the lever that moves with the clutch/brake rod is hangin up and then moving suddenly, snapping tension on the drive belt instead of gradually applying...
Small Engines (Lawn Mowers, etc.): clutch/brake pedal, craftsman model, clutch pedal
craftsman model, clutch pedal, garden tractors: Let me get this straight, the key will not start the engine. The engine starts when you push the clutch pedal. Is this correct? Do you have any idea why the wiring harness melted? This is very, very rare on garden tractors. Let me know. Eri...
Small Engines (Lawn Mowers, etc.): clutch/brake, wheelie, transaxle
wheelie, transaxle, pulley: Hi Greg- Jeeze pops a wheelie? Man- yeah you need to fix that before you break the transaxle! Sounds like the lever that moves with the clutch/brake rod is hangin up and then moving suddenly, snapping tension on the drive belt instead of gradually applying...
Small Engines (Lawn Mowers, etc.): coil on a kohler thats on a John Deere, flywheel, model numbers
flywheel, model numbers, stator: Hello Again Glen: Then the Coil May be Bad. The Coil Contains the Ignition Module on this Engine. The Component Under the Flywheel is the Stator. This is the Charging Systen for you Engine. You can View a Breakdown/IPL at this Addy http://jdpc.deere.com/jdpc/servlet/com.deere.u90490.partscatalog.view.servlets.HomePageServlet_Alt...
Small Engines (Lawn Mowers, etc.): coil on a kohler thats on a John Deere, john deere mower, flywheel
john deere mower, flywheel, model numbers: Hello Glen: Is this an OLder Engine? If Yes, then the Point Set May need Replacing. Send me the Model Numbers Off the Engine, Please. With these I can Locate a Breakdown/IPL of the Engine and Better Assist you. Thanks. Respectfully Joh...
Small Engines (Lawn Mowers, etc.): coil, electronic ignition modules, auto parts stores
electronic ignition modules, auto parts stores, impact gun: Dirty or wore points will cause it to pop and backfire as you described. You can replace the points, condenser and inspect the plunger but I would recommend using one of those electronic ignition modules. You can find them at many auto parts stores and...
Small Engines (Lawn Mowers, etc.): coil, rmp, electronic ignition
rmp, electronic ignition, briggs: It s possible that the coil could break down or you may have points in that engine. 81 was the first year Briggs went to electronic ignition but some engines may have points in them. How if the engine running at high rmp? Surging or cutting out? Let...
Small Engines (Lawn Mowers, etc.): coleman 1850 wont start, happy thanksgiving, code numbers
happy thanksgiving, code numbers, model type: Hello Sal: Is the Spark Plug Firing? Send me the Make, Model, Type and Code Numbers Off of the Engine, Please. With these I can Locate a Breakdown of the Engine and Better Assist you. Does this Unit have the Low Oil Shutoff? Thanks. Respectfully...
Small Engines (Lawn Mowers, etc.): coleman powermate generator
Hello Charles: Install a New Wire from the Coil Connection Point to the Switch. Does this Cure the Problem? There Has to Be a Ground in the Wire if the Switch is Good. Be Sure to Use Wire Ties and Fasten the New Wire Securly so it Isnt Moving Around...
Small Engines (Lawn Mowers, etc.): coleman powermate generator, coleman powermate generator, coleman generator
coleman powermate generator, coleman generator, wire ties: Hello Charles: Install a New Wire from the Coil Connection Point to the Switch. Does this Cure the Problem? There Has to Be a Ground in the Wire if the Switch is Good. Be Sure to Use Wire Ties and Fasten the New Wire Securly so it Isnt Moving Around...
Small Engines (Lawn Mowers, etc.): compression check, briggs stratton engine, briggs stratton
briggs stratton engine, briggs stratton, compression release: Hello Larry: On the Newer Engines there is a Compression Release on the Cam that Opens a Valve for the Compression Release. The Duration of the Valve Being Open Doesn t Effect the Engine while Running. It Effects the Engine Operation During Starting...
Small Engines (Lawn Mowers, etc.): compression release, briggs and stratton, starter rope
briggs and stratton, starter rope, compression release: Hello Bob: A Damaged Flywheel Key will cause this Problem Also. To Correct the Problem if it is the Compression Release, the Valve Lash has to be ReAdjusted. Is the Engine Overfilled with Oil? Too Much Oil will cause the same Problem. You can View a...
Small Engines (Lawn Mowers, etc.): compression testing
Hello Roberto: Even with the Compression Release the Compression I Look for is 70PSI Minimum. How do the Engines Run? If the Compression Reslease is Set Close, you May get only 60PSI. I have had this Happen a Few Times and have Found that was the Case....
Small Engines (Lawn Mowers, etc.): compression testing, compression tester, compression release
compression tester, compression release, cylinder pressure: Hello Roberto: Even with the Compression Release the Compression I Look for is 70PSI Minimum. How do the Engines Run? If the Compression Reslease is Set Close, you May get only 60PSI. I have had this Happen a Few Times and have Found that was the Case....
Small Engines (Lawn Mowers, etc.): compression, cold cranking amps, bolt torque
cold cranking amps, bolt torque, riding lawn mower: I ve never heard of double head gaskets, but it would definitely lower the compresison ratio. Have you checked or replaced the battery or battery cables lately? We had a Snapper do the same thing once, and we replaced cables and ran a new, heavier wire...
Small Engines (Lawn Mowers, etc.): compression, compression release, good luck
compression release, good luck, oem: Hello Sheldon: The Lowest Compression is 90psi. The OEM Says to Turn the Engine in Reverse Rotation and if there is KICK BACK the Compression is Good. I Remove the Valves and Install Special Valves I have Designed to Test Compression on the Newer Engines...
Small Engines (Lawn Mowers, etc.): compression, lawn mower batteries, compression point
lawn mower batteries, compression point, cable problems: Great trouble-shooting. Have you checked the flywheel key? Usually tractor engines do not shear keys, but I always check. Secondly, did you check the push rods? I have found several bent push rods. A cheap, accurate method to check the push rods is...
Small Engines (Lawn Mowers, etc.): compression, lawn mower batteries, real stumper
lawn mower batteries, real stumper, spark plug wire: A lot of engines backfire these days. EPA standards have required the engine manufacutures to produce clean burning engines, so they lean the fuel mix. The solenoid on the bottom of the carb is supposed to shut-off the fuel when the key is turned off to...
Small Engines (Lawn Mowers, etc.): compression, lawn mower batteries, real stumper
lawn mower batteries, real stumper, spark plug wire: A couple of thousands off can make a huge difference in compression. In the old days, the L-head cylinders, we d grind a thousandsth or more off the intake to increase compression...but grinding too much prevented you from pulling the string. Let me know...
Small Engines (Lawn Mowers, etc.): continuation of 18 hp briggs & stratton, blown head gasket, overhead valve engine
blown head gasket, overhead valve engine, john deere tractor: Hello Tony: Lets Check the Push Tubes for the Valves. This is an Overhead Valve Engine. Look for Anything like a Bent Push Tube, Loose Rocker Arm, Rocker Arm Not Moving. If this is Working Good, Then Look for a Blown Head Gasket. Go to this Addy http://shop.briggsandstratton.com/BShopProductListingPage.asp?rsvp=0&PARENTID=0&SessionID=43C7B3A0-6A44-4EB2-B2CC-23B437198A68&MECID=100&CATALOGID=56B2B9A7-283C-11D4-8886-00B0D0203414...
Small Engines (Lawn Mowers, etc.): control springs, briggs and stratton, swivel plate
briggs and stratton, swivel plate, throttle valve: Hello Stephanie: Go to this Addy http://www.outdoordistributors.com/ and Select the B. Then Select Briggs and Stratton. Then Select Don t have Part Numbers. Then Select the File # 10. Then Select the Folder 10A900. On Page 5 of 16; Can you Tell me which...
Small Engines (Lawn Mowers, etc.): converting a lawnmower engine for a hovercraft, belts and pulleys, horizontal shafts
belts and pulleys, horizontal shafts, vertical shaft: Belts and pulleys could work but it would be easer to use the correct engine. Horizontal shafts run side-to-side, vertical shafts run top-to-bottom. I m assuming the vertical shaft would have the fan bolted directly to the crankshaft. You can not turn...
Small Engines (Lawn Mowers, etc.): craf cultivator/edger model no.316.29270, breather vent, crankcase breather
breather vent, crankcase breather, adjustment screws: Hello Chris: Sorry for the Delay. This Question was Located in the Question Pool. Change the Oil. Does it have a Gas Smell to it? You can View a Breakdown/IPl at this Site Addy, http://www3.sears.com/ and Enter the Model Numbers at the Upper Left Search...
Small Engines (Lawn Mowers, etc.): crafstman # for overhauling, briggs and stratton, tractor model
briggs and stratton, tractor model, lawn equipment: Hello Cory: You can View a Breakdown of the Engine at this Addy http://www.outdoordistributors.com/ and Click the B. Then Click Briggs and Stratton. Then Click Dont have Part Numbers. Then Scrool Down to the File Number 28 and Click. Then Scroll Down...
Small Engines (Lawn Mowers, etc.): crafstman 6.0 mower, carburator, delivery problem
carburator, delivery problem, fuel delivery: Hiya Jeffrey Sounds like a fuel delivery problem for sure. Drain your tank, put a little more gas in it, slosh it around, drain again. Under the carburator theres a fuel bowl. Remove the the single large screw holding in on and let it drain. Now add...
Small Engines (Lawn Mowers, etc.): craftman 20, fuel flow, spark plug
fuel flow, spark plug, electrode: Hi Kathy, The air filter needs to be clean and allow air to enter the carb. Look for a 4x4 inch box with a screw securing it s cover. Remove and clean the filter with compressed air or replace it if it is very dirty. If no change, you will need to...
Small Engines (Lawn Mowers, etc.): craftman 3hp reserve power edger motor, craftman, change oil
craftman, change oil, ok heres: Hi Josh, If it only runs when you add staring fluid to the carb, then there is a lack of fuel flow to the engine. First try adjusting the carb mixture screws. If that doesn t help, I then would suspect dirt, debris, water or gummed fuel in the carb. ...
Small Engines (Lawn Mowers, etc.): craftman 3hp reserve power edger motor, metal tab, battery ignition
metal tab, battery ignition, craftman: Hi Josh, Each and every carb opening must be clean. Sometimes a small wire is needed to open them. You can add a metal tab to ground the spark plug boot but without a battery ignition there are probably no wires that can be grounded, for use as a kill...
Small Engines (Lawn Mowers, etc.): craftman dyt 4000 transaxle won,t pull, dana spicer, foote transaxle
dana spicer, foote transaxle, transaxle: Hello Larry: Send me the Model Numbers Off the Mower, Please. If you have the Make and Model Numbers of the Transaxle they will Help also. Is this a Dana, Spicer or Foote Transaxle? There are Many Different Transaxles on the Market and I want to be...
Small Engines (Lawn Mowers, etc.): craftman dyt 4000 transaxle won,t pull, woodruff key, foote transaxle
woodruff key, foote transaxle, dana spicer: Hello Larry: The Breakdown/IPL/Diagragm I am Looking at is at this Addy http://www.m-and-d.com/dana_foote_parts.html and Scroll Down to the View Dana/Foote Parts Diagragms. Spicer/Dana/Foote are from the Same OEM. Have you Disassembled the Shafts and...
Small Engines (Lawn Mowers, etc.): craftman lawn tractor- no sparks, safety switches, tractor model
safety switches, tractor model, sectional view: Hello Carlos: Check the Seat Safety Switch. If this is Bad the Engine Can t Fire the Plug. There are No Point Set for this Engine. It is Electronic Ignition(Coil) and these Seldom are a Problem. There are Numerous Switches that will Cause the Coil Not...
Small Engines (Lawn Mowers, etc.): craftman lawnmower
Hello Sheranda: It Sounds like Trash has Gotten Into the Carb Jet. Let the Mower Cool. Does it Run and Quit in 3 to 5 Seconds Still? If so the Jet Does have Trash in it. The Carburator needs to be Cleaned and Overhauled. If it Runs for 5 inutes or...
Small Engines (Lawn Mowers, etc.): craftman lawnmower ( push mower ), engine oil, air compressor
engine oil, air compressor, air filter: Normally the inlet needle inside the carb does not seat for what ever reason; maybe some dirt, water, or even bad gas. We remove, dis-assemble and clean the carb with compressed air from an air compressor. Usually we replace the needle and seat as well....
Small Engines (Lawn Mowers, etc.): craftman lawnmower, inutes, gas filter
inutes, gas filter, carburator: Hello Sheranda: It Sounds like Trash has Gotten Into the Carb Jet. Let the Mower Cool. Does it Run and Quit in 3 to 5 Seconds Still? If so the Jet Does have Trash in it. The Carburator needs to be Cleaned and Overhauled. If it Runs for 5 inutes or...
Small Engines (Lawn Mowers, etc.): craftman push mower, john harte, carburator
john harte, carburator, push mower: Hello John: The Carburator needs to be Soaked Overnight in Cleaning Solution(not the Plastic Carburator). Then Blow All the Passages Out with Compressed Air. The Plastic Carburator has to Be Soaked for 1 hr at a Time and Blown out with Compressed Air...
Small Engines (Lawn Mowers, etc.): craftman riding mower, safety switches, soleniod
safety switches, soleniod, battery check: Hello Phil: If you are not getting anything from the Soleniod then Check all the Safety Switches. Does the Starter turn if jumped directly to the Starter; if so then one of the Safety Switches is bad or not making contact. Hope this Helps. Good...
Small Engines (Lawn Mowers, etc.): craftman tiller wont idle, engine numbers, model numbers
engine numbers, model numbers, tiller: Hello Don: Send me the Model Numbers Off of the Engine, Please. Also Does the Engine Run and Quit after a few Seconds Over and Over Again? Does it Run at Full Throttle Only? With the Engine Numbers I can View a Breakdown of the Engine and Better Assist...
Small Engines (Lawn Mowers, etc.): craftmans 7.0 HP mower and mulcher
Hello Steve: The Most Common Problem is the Carburator. The Next Time it Wont Start, Do a Diagmostic as Follows. Check for Fire at the Spark Plug. If the Plug is Firing, then Try to Start the Engine with Starter Fluid. If it Starts and Quits, then the...
Small Engines (Lawn Mowers, etc.): craftmans 7.0 HP mower and mulcher
Hello Steve: After Viewing the Breakdown, I am Still Suggesting the Carburator. Do you use any Gas Stabilizer? If yes, then dont. I have found the Stabilizer Damages the Gaskets Inside the Carburator. Hope this Helps. Let me know what Happens, Please....
Small Engines (Lawn Mowers, etc.): craftmans 7.0 HP mower and mulcher, starter fluid, carburator
starter fluid, carburator, model numbers: Hello Steve: The Most Common Problem is the Carburator. The Next Time it Wont Start, Do a Diagmostic as Follows. Check for Fire at the Spark Plug. If the Plug is Firing, then Try to Start the Engine with Starter Fluid. If it Starts and Quits, then the...
Small Engines (Lawn Mowers, etc.): craftmans 7.0 HP mower and mulcher, gas stabilizer, hp power
gas stabilizer, hp power, rear discharge: Hello Steve: After Viewing the Breakdown, I am Still Suggesting the Carburator. Do you use any Gas Stabilizer? If yes, then dont. I have found the Stabilizer Damages the Gaskets Inside the Carburator. Hope this Helps. Let me know what Happens, Please....
Small Engines (Lawn Mowers, etc.): craftmen 25cc weed wacker, air mixture, throttle plate
air mixture, throttle plate, rocky 1: Hello Rocky: 1- If the Spark Plug is Firing, then the Coil is Usually Good. 2- Here is the Instructions that has the Carburetor Settings in them. **The High Air Mixture Screw is In the Carburetor Bowl in the Center of the Nut or Some Carburetors have...
Small Engines (Lawn Mowers, etc.): craftsman 10hp riding mower, compression test, exhaust valve
compression test, exhaust valve, intake valve: Hi Daryl, Fuel spitting from the carb indicates a leaky intake valve. Exhaust popping could be an exhaust valve. You could do a compression test to confirm this. Then check the valves. They may be lacking clearance, sticking or need reseating. Let...
Small Engines (Lawn Mowers, etc.): craftsman 12 HP lawnmower, briggs and straton, craftsman riding lawn mower
briggs and straton, craftsman riding lawn mower, hp briggs: There is a problem with either the needle and seat or the float. You need to remove the carb and inspect the inlet needle and seat for wear and replace accordingly. If the float is the problem, it won t float because it has a hole in it (you should hear fuel...
Small Engines (Lawn Mowers, etc.): craftsman 12 hp riding lawn mower, briggs and straton, craftsman riding lawn mower
briggs and straton, craftsman riding lawn mower, gas leaks: Hi Mike, The leaking is most likely due to a carb float problem. Either the float is fuel logged and heavy or the floats valve and seat are worn or have a piece of debris stuck between them. The mower shuts off when the blades are engeged due to a...
Small Engines (Lawn Mowers, etc.): craftsman 15hp b+s, pivot pin, air filter
pivot pin, air filter, fuel system: It s likely that the needle and seat are not sealing and fuel is running into the carburetor throat. This can be caused by a worn needle and/or seat or dirt under the inlet needle. It can also be caused by the float having a leak or the pivot pin not allowing...
Small Engines (Lawn Mowers, etc.): craftsman 19.5 briggs mower
Most likely the problem is a dirty carburetor. This is the most common problem we see. I would start by removing, dis-assembling and cleaning the carb with compressed air from an air compressor and using some carburetor cleaner. You carb is probably...
Small Engines (Lawn Mowers, etc.): craftsman 19.5 briggs mower, wd40, airfilter
wd40, airfilter, fuel delivery: Most likely the problem is a dirty carburetor. This is the most common problem we see. I would start by removing, dis-assembling and cleaning the carb with compressed air from an air compressor and using some carburetor cleaner. You carb is probably...
Small Engines (Lawn Mowers, etc.): craftsman 2 cycle edger, flat screwdriver, walbro carb
flat screwdriver, walbro carb, exhaust port: .025 on the plug. As for the needles, 1 and 1/4 to 1 and 1/2 turns out from the GENTLY seated position. DO NOT OVER TIGHTEN because you can damage the carburetor. A small, pocket size, flat screwdriver or just your fingers works well to GENTLY seat the...
Small Engines (Lawn Mowers, etc.): craftsman 2 cycle edger, flat screwdriver, walbro carb
flat screwdriver, walbro carb, exhaust port: You need a compression tester to check compression. It should be about 90 PSI. As for the muffler/exhaust port, remove the muffler, check the port for carbon build-up and then, if possible take the muffler apart and clean the carbon build-up from the muffler...
Small Engines (Lawn Mowers, etc.): craftsman 32cc gas weedwacker model 358.795580, bottom hole, throttle cable
bottom hole, throttle cable, poulan: Hello Susan: You can View a Breakdown/IPL for this Trimmer at this Addy http://www3.sears.com/ and Click the Lawn Equipment Box. Then Follow the Instructions to the View Parts List/View Diagram Page. Recheck the Route of the Cable. If the Cable Routing...
Small Engines (Lawn Mowers, etc.): craftsman 4.5 wont start
Hello Sandra: It Sounds like the Carburator needs to be Cleaned and Rebuilt. It should Only take 3 or 4 times Pushing the Primer to Choke the Engine. The Running for a Few Seconds and Quits is a Good Indicator of the Carburator being Clogged with Trash/Water...
Small Engines (Lawn Mowers, etc.): craftsman 4.5 wont start, carburator, dark smoke
carburator, dark smoke, code numbers: Hello Sandra: It Sounds like the Carburator needs to be Cleaned and Rebuilt. It should Only take 3 or 4 times Pushing the Primer to Choke the Engine. The Running for a Few Seconds and Quits is a Good Indicator of the Carburator being Clogged with Trash/Water...
Small Engines (Lawn Mowers, etc.): craftsman 4cyl weedeater, grounding wire, starter fluid
grounding wire, starter fluid, full tank: Hello Dace: Check the Fire at the Plug. Remove the Plug and Wrap a Grounding Wire Around the Threads. Attach the Other end of the Grounding Wire to the Engine. Does the Plug Spark? If No, then Disconnect the Shutoff Switch. Does the Plug Spark? If Yes,...
Small Engines (Lawn Mowers, etc.): craftsman 6 hp eager-1, harmonic style, eager 1
harmonic style, eager 1, sears: Usually a sheared key will cause it not to start at all but if something was hit, it would be wise to check the flywheel key and the blade hub before you proceed any further. You need to remove the blower/starter housing to gain access to the flywheel. Then...
Small Engines (Lawn Mowers, etc.): craftsman 6.25 hp self-propel lawmower, bolt torque, rod bolts
bolt torque, rod bolts, rod bolt: Those Tecumseh engine rod bolts are know to come loose...I have found a lot of busted connecting rods because a rod bolt came loose. I highly doubt the blade adapter key would cause the oil consumption, but it will definitely cause the knock. A loose blade...
Small Engines (Lawn Mowers, etc.): craftsman 6.5 mower
Hello Kurt: 1-Remove and Check the Exhaust Port and Muffler for Blockage. 2- The Carburator May have Pulled Trash/Water Into it. Also the Gas Forms a Varnish and Restricts the Gas Flow Through the Ports and Passages Inside the Carburator. Soak the Carburator...
Small Engines (Lawn Mowers, etc.): craftsman 6.5 mower, briggs and stratton, acre of land
briggs and stratton, acre of land, carburator: Hello Kurt: 1-Remove and Check the Exhaust Port and Muffler for Blockage. 2- The Carburator May have Pulled Trash/Water Into it. Also the Gas Forms a Varnish and Restricts the Gas Flow Through the Ports and Passages Inside the Carburator. Soak the Carburator...
Small Engines (Lawn Mowers, etc.): craftsman 6.75 briggs & stratton engin, briggs stratton, starter rope
briggs stratton, starter rope, new spark: Did you drain some of the oil out of the engine? Is the air filter saturated with oil? You may want to remove the spark plug and pull the starter rope several times to drain any oil from the cylinder. With the mower on concrete, remove the air filter...
Small Engines (Lawn Mowers, etc.): craftsman 6.75 briggs & stratton engine, briggs stratton engine, briggs stratton
briggs stratton engine, briggs stratton, dipstick tube: I would replace the filter. The drain plug is located on the bottom of the engine. If you have a self-propel model the drain plug may be covered by belt guards. It may be easier to have a second person help you drain the oil out of the dipstick tube by...
Small Engines (Lawn Mowers, etc.): craftsman 6.75hp push mower, t touch, code numbers
t touch, code numbers, model type: Hello Steve: Follow the Engine Brake/Shutoff Cable from the Handle to the Engine. Locate the Engine Brake/Shutoff Bracket. There is a Wire coming from Under the Blower Housing, going to a Cutoff Blade. Remove this Wire from the Blade and Make Sure this...
Small Engines (Lawn Mowers, etc.): craftsman 8hp riding mower, oil leak, pulley
oil leak, pulley, gasket: Check the seal on the bottom of the engine. You may have to remove the pulley to see the seal. Does the engine have compression? I would also check the gasket on the lower part of the engine. You may want to degrease the engine...this will help find...
Small Engines (Lawn Mowers, etc.): craftsman 917-378750, craftsman 917, sears
craftsman 917, sears, lawn equipment: Hello Mike: Try Contacting Sears at this Addy http://www3.sears.com/ and Click on the Lawn Equipment Box. Then Enter the Model Numbers and Click Go. Then Verify the Mower and Click Go. Now Enter the Word Manual in the Search Box. The Owners Manual will...
Small Engines (Lawn Mowers, etc.): craftsman 917.377521 lawnmower, craftsman 917, ring gasket
craftsman 917, ring gasket, debri: Its clogged inside from either stale fuel, debri, or water, clamp the fuel line and remove the the small bolt in the bottom of the bowl and remove the bowl look inside the bowl if its brown its stale fuel, or you may find debri or water either way youi need...
Small Engines (Lawn Mowers, etc.): craftsman DYT 4000 riding mower, repair trip, snow chain
repair trip, snow chain, cable ends: Have you dis-connected and cleaned the battery terminals and cable ends with a wirebrush? I m guessing it is a safety switch. Most mowers have a switch on the seat, clutch/neutral switch and somewhere along the blade engageing system. Are all the levers...
Small Engines (Lawn Mowers, etc.): craftsman DYT 4000 riding mower, safety switches, repair trip
safety switches, repair trip, snow chain: You can go to the Sears website, under parts, type in your model number and see the schematic. You have 3 safety switches. To test the switches all you need is a multimeter. The switches are basically like a light switch in your house; on/off or closed/open....
Small Engines (Lawn Mowers, etc.): craftsman LT1000 riding mower transmision, craftsman lt1000, manual shift
craftsman lt1000, manual shift, machinist: Hi Greg, Sorry, I have never gotten into a tractors transmission. If it were mine, I would double check the clutch to make sure it is disengageing and check the shifter to make sure it is moving what it is supposed to. If all looks good, then the only...
Small Engines (Lawn Mowers, etc.): craftsman LT2000 Kohler 17hp, craftsman lt2000, vacuum problem
craftsman lt2000, vacuum problem, sears: Hello John: Clean the Vent in the Gas Cap or Replacing the Gas Cap will Cure the Vacuum Problem in the Tank. Send me the Sears Model Numbers, Please. With these I can Locate a Breakdown/IPL of the Mower and Better Assist you. It May be the Clutch Safety...
Small Engines (Lawn Mowers, etc.): craftsman LT2000 Kohler 17hp, craftsman lt2000, vacuum problem
craftsman lt2000, vacuum problem, sears: Hello John: Go to this Addy http://www3.sears.com/ and Click the Box Lawn Equipment. Then Enter the Model Numbers 917.273130 and Click Continue. Verify the Equipment is Correct and Click Continue. Select the View Diagram of the Electrical System. In...
Small Engines (Lawn Mowers, etc.): craftsman LT2000 Kohler 17hp, craftsman lt2000, vacuum problem
craftsman lt2000, vacuum problem, sears: Hello John: Did you Check the Fuse? I Sometimes Forget to Mention the Fuse. I am Sorry. It s been so Natural for me to Automatically Check the Fuse that I Don t Ask the Question. :-( I Guess I Owe you 1 this Time. If the Fuse is Blown, then Replacing...
Small Engines (Lawn Mowers, etc.): craftsman LT2000 Kohler 17hp, craftsman lt2000, vacuum problem
craftsman lt2000, vacuum problem, sears: Hello Again John: It can be 2 things. 1- the Coil/Magneto is Breaking Down and Causing an Intermittent Spark or 2- the Carburetor has Trash/Water in it and the Trash/Water is Clogging the Main Jet Temporarily and Causing the Stutter. If you are Using...